CALL US

+86 17838360708

study of marble power as partial replacement for

study of marble power as partial replacement for

STUDY OF MARBLE POWER AS PARTIAL REPLACEMENT FOR

STUDY OF MARBLE POWER AS PARTIAL REPLACEMENT FOR CEMENT MORTAR USING M-SAND GLADWIN ALX. A 1, BASKAR. R2 GANAPATY CHETTIAR 3 1Resarch Scholar, Department of Civil and Structural Engineering, Annamalai University, Chidambaram, Tamil Nadu, India 2Associate Professor, Department of Civil and Structural Engineering,

get price

Study of Partial Replacement of Cement by Marble Powder

The partial replacement of cement by marble powder is used up to M25 grade concrete. The strength decreases beyond the use of M 25 grade, but shall be improved on the addition of super plasticizer.

get price

Use of Waste Marble Powder as Partial Replacement in ...

May 18, 2015  In this experimental study, fine marble powder dust was collected from the nearby source for the investigation. Different concrete mixtures were prepared by using different percentages of marble powder like 0%, 10%, 10% and 20% as a partial replacement of cement and sand mix. The mechanical and physical properties were checked on the 7 28 days.

get price

USE OF MARBLE POWDER AS A PARTIAL REPLACEMENT OF CEMENT

project describes the feasibility of using the marble sludge dust in concrete production as partial replacement of cement and to reduce the cost of the concrete by marble

get price

Study on Marble Powder as Partial Replacement of Cement

study initiated to arrive at the feasibility and suitability of using marble powder as a partial replacement material by 0, 5, 10, 15, 20 and 25% weight of cement in M30 grade concrete. Experimentation performed and the conclusions are derived as presented

get price

Use of Waste Marble Powder as Partial Replacement in ...

using waste marble powder as partial replacement of cement and sand. Keywords: Waste marble powder, concrete, compressive strength, flexure strength, split-tensile strength, workability, durability. I. INTRODUCTION. Marble is obtained from the transformation of pure limestone. The purity of marble depends upon the colour of the marble.

get price

USE OF MARBLE POWDER AS A PARTIAL REPLACEMENT OF

1. Due to waste marble powder, it proved to be very effective in assuring very good cohesiveness of. mortar and concrete. 2. From the above study, it is concluded that the waste marble powder can be used as a partial. replacement material for cement; and 20% replacement of marble dust gives an excellent result in.

get price

Partial Replacement of Cement With Marble Powder in ...

Partial replacement of marble powder in cement accordingly in the range of 20%, 30%, 40%, by weight for M20 grade of concrete. With this experimental research work the problem of waste production management of this agro waste are will be solved.

get price

Investigation on Partial Replacement of Cement with Marble ...

Sep 04, 2020  Study on Marble Powder as Partial replacement of Cement in Concrete, Global Research and Development Journal For Engineering, 2(2), PP 77-80. [12] MSME-Development institute, (2006). Status report on commercial utilization of marble slurry in Rajasthan. [13] Nitisha Sharma and Swami Dyal, (2015). Use of Marble Powder as Partial Replacement in ...

get price

Study of Compressive Strength of Concrete by Partial ...

Marble Dust Powder, Partial Replacement. I. INTRODUCTION Marble is a metamorphic rock produced from limestone by pressure and heat in the earth's crust due to geological process [1]. Marble Dust Powder is an industrial waste produced from cutting of marble stone. In INDIA, the marble processing is one of the most flourishing industry.

get price

Evaluation of Concrete with Partial Replacement of Cement ...

This study aims to evaluate concrete having Waste Marble Powder (WMP) as partial replacement of cement. Marble is the metamorphic form of limestone (CaCO 3) and WMP was chosen as substitute of cement on account of its high calcium oxide content.WMP is by-product of marble industry and is an environmental burden.

get price

A REVIEW PAPER ON PARITALLY REPLACEMENT OF CEMENT

is to study the effect of use of marble dust as partial replacement of cement to produce concrete pavement cost effective. The effect of marble dust powder has been delibreate on the sength characterstics of concrete pavement. 2. LITREATURE REVIEW Valeria (2005) [1] He obtained that marble dust powder

get price

Partial Replacement of Fine Aggregates with Quarry Dust ...

river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

get price

Marble powder - SlideShare

Sep 11, 2016  Marble powder 1. BY P.ROHITH S.NIHARIKA A.RANJITH B.AKSHAY P.JEEVAN Partial Replacement of Cement with Marble Powder 2. Objective of the project Introduction Nominal Mx Design Test Results and Graphs Conclusion Contents 3. Composition of Marble powder 4.

get price

An Experimental investigation on utilizations of Marble ...

This study presents the feasibility of the production of concrete with marble dust as partial replacement of cement upto 20% (by weight) and to find out the optimum percentage of marble dust. The compressive strength and workability of Concrete was studied experimentally using marble dust as partial replacement of cement.

get price

Properties of Hardened Concrete Produced by Waste Marble ...

Jul 03, 2015  During the cutting process, 20-30% of a marble block becomes waste marble powder. Marble powder is a waste material generated in considerable amounts in the world. Marble waste leads to a serious environmental problem as well. ... Study on marble dust as partial replacement of cement in concrete. Indian Journal of Engineering, 4 (2013), pp. 14-16.

get price

Study On Partial Replacement Of Cement With The ...

Dr. Priya V, Chinmaya Patil, Nitesh Bhatt, Bruhan Sampangi Rama, and Aditya Joshi, "Study On Partial Replacement Of Cement With The Combination Of Glass Powder And Marble Dust," International Journal Of Advance Research And Innovative Ideas In Education, vol.

get price

Comparative Study on Effect of Chloride and Water on ...

[2]“To Study the Behaviour of Marble Powder as Supplementary Cementitious Material in Concrete”,(2014) 2,Pooja J.Chavhan, Prof. S. D. Bhole. ISSN 2248-9622. ISSN 2248-9622. [3]“Study on marble dust as partial replacement of cement in concrete”,(2013) 3, Saveetha University,

get price

IJERT-Use of Waste Marble Powder as Partial Replacement in ...

Different mixes was testing was also conducted by using a 100kN capacity prepared by using a different percentage of marble powder electrically operated flexural testing machine at a (0%, 10%, 10% and 20%) namely MX0, MX1, MX2 MX3 displacement rate of 0.05 mm/sec. Water absorption test was as a partial replacement in the cement sand mix, where ...

get price

Research Paper PARTIAL REPLACEMENT OF CEMENT WITH

PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST POWDER Prof. P.A. Shirule a*, Ataur Rahman b , Rakesh D. Gupta c Address for Correspondence a*bc Dept. Of Civil Engineering, SSBT’s COET, Bambhori, Jalgaon, Maharashtra – 425001 ABSTRACT Leaving the waste materials to the environment directly can cause environmental problem.

get price

Evaluation of Concrete with Partial Replacement of Cement ...

This study aims to evaluate concrete having Waste Marble Powder (WMP) as partial replacement of cement. Marble is the metamorphic form of limestone (CaCO 3) and WMP was chosen as substitute of cement on account of its high calcium oxide content.WMP is by-product of marble industry and is an environmental burden.

get price

(PDF) IRJET- PARTIAL REPLACEMENT OF CEMENT WITH MARBLE ...

OBJECTIVE OF THIS STUDY Study of the effect of using Marble Dust Powder as a replacement and Polypropylene as admixture in concrete and its benefits. Improve the overall durability and long-term performance of concrete structures. An approach towards the use of the alternative materials as concrete thereby reducing the burden on main ...

get price

A REVIEW PAPER ON PARITALLY REPLACEMENT OF CEMENT

is to study the effect of use of marble dust as partial replacement of cement to produce concrete pavement cost effective. The effect of marble dust powder has been delibreate on the sength characterstics of concrete pavement. 2. LITREATURE REVIEW Valeria (2005) [1] He obtained that marble dust powder

get price

A study of the chemical effect of marble and granite ...

Feb 04, 2020  A distinctive study was undertaken by Abhishek and Pradeep to examine the effect of partial replacement of sand with granite quarry dust and cement with marble powder in concrete. The results indicated that the compressive strength increased gradually by adding up to 10% replacement of cement with marble powder and 20% replacement of fine ...

get price

Partial Replacement of Fine Aggregates with Quarry Dust ...

river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

get price

Study of the Effects of Marble Powder Amount on the Self ...

The marble powder (MP), obtained from waste sludge marble processing, has a high specific surface area; this could mean that it can be used as filler added to self-compacting concrete (SCC). The aim of this experimental work is to study the effects of the cement-MP paste volume on the rheology in the fresh state and the hardened properties (compressive strength) of SCC by a microstructure ...

get price

Marble powder - SlideShare

Sep 11, 2016  Marble powder 1. BY P.ROHITH S.NIHARIKA A.RANJITH B.AKSHAY P.JEEVAN Partial Replacement of Cement with Marble Powder 2. Objective of the project Introduction Nominal Mx Design Test Results and Graphs Conclusion Contents 3. Composition of Marble powder 4.

get price

HuberCrete Calcium Carbonate as a Partial Replacement for ...

replacement for fly ash. It suffers from a somewhat limited supply situation also, and usually at an increased cost. Powdered limestone (HuberCrete® calcium carbonate) has been previously examined as a potential partial replacement for cement. Finely ground limestone with a controlled particle size gives acceptable properties for

get price

Influence of Marble Powder Mortar and Concrete Mix

Influence of Marble Powder on Mechanical Properties of Mortar and Concrete Mix. This paper aims to focus on the possibilities of using waste materials from differentmanufacturing activities in the preparation of innovative mortar and concrete. The use of waste marble powder (dust) was proposed in partial replacement of cement, for the ...

get price

Marble Powder As A Partial Replacement Of Sand - 1454 ...

Marble Powder As A Partial Replacement Of Sand. V. CONCLUSION From the test results it is clearly evident that granite powder as a partial replacement of sand proves to be beneficial when Durability properties of Concrete is considered. Durability of Concrete using Granite Fines is almost same as that of reference mix (GF0), However at 30% ...

get price

Partial Replacement of Cement with Quarry Dust and Rice ...

study of concrete mix design using marble powder and quarry dust. This disposal of marble powder from the marble industry is of environmental problem today. Then the used for replacement process 25 grade concrete. The partial replacement of mix design of concrete. As percentage replacement of 20%, 25%, 30% are used in marble powder

get price

Annamalai University

A .Gladwin Alex Dr.R. Baskar C. GanapathyChettiyar, "Study of Marble Power as Partial Replacement for Cement Mortar using M-Sand (Scopus Index).", Journal of Civil, Structural, Environmental, Water resources and Infrastructure Engineering Research, Volume 5, Number 1, Jun 2015, pp. 21-30. 2015.

get price